Do golf cart chargers have fuses?

Publish date: 2023-03-19
The internal AC fuses of the charger do not typically give problems but a simple continuity test will show them to be good or bad. Find the charger fuses in the service panel on the back fender of the golf cart. If the battery charger fuse is blown the battery won't get a charge.

Keeping this in consideration, why is my golf cart charger not working?

When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries. If no click is heard the problem is either that the battery voltage is too low (less than 35 DC volts) or there is a problem with the OBC or a fuse.

Beside above, how do you know if your golf cart charger is working? Turn on the battery charge to see if any power is getting to the battery. You can check the amount of power the battery charger is generating by conecting a voltmeter to the negative and positive clamps of the charger. On the voltmeter is a needle moves from left to right to demonstrate amps present.

Moreover, do golf carts have fuses?

Golf carts serve a greater need than just driving on the golf course. Many hardware stores carry fuses that are compatible with those in a golf cart. A blown fuse can also mean there is an electrical problem.

How many amps should my golf cart charger show?

The ammeter on a 36-volt charger should show at least 15+ amps when the charger is plugged into the golf car, even if the batteries have not been used for a short while. A 15+ amp reading shows that the charger is actually charging, not just humming (humming is NOT an indication that the charger actually works).

How much does it cost to replace the batteries in a golf cart?

The general consensus for battery replacement ranges from $800 on the low end to $1500 on the high end. Some packs cost as much as $2000 when you start dealing with 72 Volt systems and sealed batteries. But, for the typical lead acid battery pack, $900 to $1500 is about the norm.

How do you bypass a solenoid on a golf cart?

Turn on the engine of the cart and press the pedal downwards. If you hear a clicking sound, then it means that the low side voltage is working. But, if there is no such sound, it means that either there is no low side voltage or there is a problem with the solenoid. Use a voltmeter and engage the solenoid.

Can you replace one battery on a golf cart?

The reason is that a deep cycle golf cart battery will not exhibit signs of needing replacement until after they are fully discharged. If one battery is bad, though, then we do recommend replacing all the batteries at once since it will cost more in the long run to replace one battery at a time.

Can you overcharge a golf cart battery?

Overcharging your golf cart batteries may damage them. It is best to use an automatic charger that turns itself off when a battery is fully charged. Some older models lack this important feature. Do not drive the vehicle until the battery dies; lead-acid batteries won't last as long if you completely discharge them.

How Far Will electric golf cart go?

A gas cart tank usually has a 6 gallon capacity and this will enable you to travel approximately 250 miles. An electric cart will go between 25 and 40 miles depending on your battery configuration.

Can golf cart chargers get wet?

Newer models are semi sealed but they can't be submerged in water because the wire connections are not sealed. Golf carts are not made for underwater operation. The exspense of water proofing the charger is cost prohibitive and deemed unnecessary.

How long should batteries last in a golf cart?

That all being said, properly maintained battery packs in fleet carts tend to last about 4-6 years while private owners tend to get about 6-10 years out of their battery packs.

How do you get 12 volts from a 36 volt system?

If you have a 36-volt electrical system then it is easy to 'tap' into 12-volts. Wire the 'hot' lead to a positive battery terminal and run the ground wire back to the negative battery terminal on the next battery over that is connected to the first one. DO NOT wire the ground to the frame of the car…

How much does it cost to charge a golf cart?

I was told by my electric company that the average cost to charge batteries is 27 cents per day, charging them once daily. I live in a community where there are more than 100 miles of golf cart paths. I use my golf cart for daily transportation to and from work and to run local errands.

Can I leave my golf cart plugged in all winter?

Store Golf Cart and Batteries in a Cool/Dry Place DO NOT leave charger plugged in all winter! This can permanently damage your golf cart's batteries. If you can't recharge the batteries once per month, then be sure to disconnect the first battery cable from the golf cart.

Can you use 4 12v batteries in a golf cart?

In a 48 volt golf cart you can use 4 12 volt batteries in place of 6 8 volt batteries. These need to be connected in series (negative to positive) in order to create 48 volts from the battery pack. Also new hold down rods and plates will be required to fit the 12V batteries.

How long will a 48v golf cart run?

The average drive time or range for a 36 volt DC system is about 30 miles on a full charge. The 48 volt golf cart offers many more advantages in all 2, 4 or 6 passenger models. They are designed to be used in hilly areas and they offer extended range about 40-45 miles between charges compared to the 36 volt cart.

Can I use regular deep cycle batteries in my golf cart?

The Technical Answer: Yes. It's possible to use a marine battery in place of electric golf cart batteries. They're both technically gel lead acid batteries designed for deep-cycle purposes, reports It Still Runs. However, this similarity doesn't mean that they should be used interchangeably.

What should a golf cart battery charger read?

Almost all older golf cart battery chargers provide 36 volts although there are some early 24 volt and 48 volt systems as well. Most of these early chargers will turn on and try to charge any 36-volt battery pack into which they are plugged…they don't care what the existing battery voltage happens to be.

What is the third wire on a golf cart charger?

The third wire supplies 4.7 volts to the electronics of the cart. On mine there is an LED light in the receptacle which comes on. The 4.7 volts also disables the cart from being operated. The charger itself senses the current draw of the 4.7 volt line and tells the microprocessor to turn on the charger.

How often should you charge a golf cart?

Still, golf cart batteries should be recharged after four hours of use. Nobody likes to be stranded. It takes several hours to re-charge golf cart batteries that have gone completely dead. To lengthen the lifespan of batteries, make sure they are fully charged before each use.

Can you charge golf cart batteries with a regular charger?

So long as you are charging one battery for 12 volt or pairs you will be fine. Most car chargers or automotive solid state chargers will activate regardless of voltage. Chargers that are microprocessor controlled give you a fault code for low voltage. You can charge 8 volt batteries in pairs just like 2 6 volt.

ncG1vNJzZmiemaOxorrYmqWsr5Wne6S7zGibqGWXpLmnecKaqa1lk52us7PEq6pmoJGrsm6y1KycrA%3D%3D